Measurement and characterization of "resonance friction" at high sliding speeds in a model automotive wet clutch

Sie sind hier: Homepage > Suche

Measurement and characterization of "resonance friction" at high sliding speeds in a model automotive wet clutch

Banquy, Xavier / Lowrey, Daniel D. / Belman, Nataly / Min, Younjin / Mordukhovich, Gregory / Israelachvilli, Jacob N.

The friction forces between various lubricated 'friction materials' and sapphire disks were measured using a new 'high-speed' rotating disk attachment to the surface forces apparatus (SFA). Two different clutch lubricants and two different friction materials were tested at sliding speeds and normal loads from 5 to 25 m/s, and 0.2 to 1 N (nominal pressures ~ 1 MPa), respectively. The results show that 'resonance friction'characterized by large amplitude oscillatory (i.e., sinusoidal) vibrations, also known as shudder or chatterdominates dynamical considerations at high sliding speed, replacing the smooth sliding or low-amplitude stick-slip that is characteristic of low speed/low load sliding. The characteristic (rotational) speeds or frequencies at which resonance friction occurs depend only on the coupled/uncoupled mechanical resonance frequencies of the loading and friction-sensing mechanisms. In contrast, the intensity of and time to enter/ exit shudder depends strongly on the lubricating oil and, to a lesser extent, on the friction material. Physical-chemical analyses of the friction materials before and after testing showed that the samples undergo primarily structural rather than chemical changes. Our results provide new fundamental insights into the resonance friction phenomenon and suggest means for its control.

Zugriff

Zugriff über TIB

Verfügbarkeit in meiner Bibliothek prüfen

Bestellung bei Subito €

Exportieren, teilen und zitieren

Dokumentinformationen

Titel :

Measurement and characterization of "resonance friction" at high sliding speeds in a model automotive wet clutch

Weitere Titelangaben:

Messung und Charakterisierung der 'Resonanzreibung' bei hohen Gleitgeschwindigkeiten in einem Kraftfahrzeug-Nasskupplungsmodell

Beteiligte:

Banquy, Xavier (Autor:in) / Lowrey, Daniel D. (Autor:in) / Belman, Nataly (Autor:in) / Min, Younjin (Autor:in) / Mordukhovich, Gregory (Autor:in) / Israelachvilli, Jacob N. (Autor:in)

Erschienen in:

Tribology Letters ; 43 , 2 ; 185-195

Erscheinungsdatum :

2011

Format / Umfang :

11 Seiten, 9 Bilder, 2 Tabellen, 17 Quellen

ISSN :

1023-8883

DOI :

https://doi.org/10.1007/s11249-011-9793-7

Medientyp :

Aufsatz (Zeitschrift)